FLUID CAPACITY CHART
E 2004 Volkswagen of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are
reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.
3of7
MY /
VEHICLE
ENGINE OIL¡
(Rev 1 1/04)
MANUAL TRANS.©
(Rev 1 1/04)
AUTOMATIC
TRANS.¢
DIFFERENTIAL
AUTOMATIC TRANS.£
COOLING SYSTEM
¤
POWER
STEERING ¥
WINDSHIELD
WASHER ¦
A/C REFRIGERANT
R-134a
A/C REFRIGERANTOIL
§
New
Beetle
Conv.
2004
w/filter change
1.8T (AWV)
4.2L (4.4qt)
2.0 (BGD)
4.0L (4.2 qt)
02M
2.3L (2.4qt)
02J
2.0L (2.1 qt)
09G
Initial fill: 7.0L
(7.4 qt)
Filled for life,
no change.
See VESIS
for filling after
repairs
Capacity included with
Automatic Transmission.
See VESIS for fillng after
repairs
1.8T (AWV)
2.0 (BGD)
5.0L (5.3 qt)
0.7-0.9L
(0.74-0.95qt)
2.0L (2.2 qt) 700+50 g
(24.7+1.8 oz)
135 cc
(4.6+
0.5 fl. oz)
¡ENGINE OIL: Approximate quantities! Use petroleum or synthetic based oils meeting following requirements:Either VW502 00,VW500 00 or VW501 01,
ACEAA3.APIserviceSJ.Useviscosity5W40ifavailable,5W30ifnotavailable.Donotoverfill! Overfillingengineoilcan causemisfireDTC’stobestoredinEngine
Control Module (ECM) -J220-. To prevent overfilling, add approx. 0.5L less than capacity, start engine and let run until engine operating temperature is approx.
60_C (140_F), turn OFF ignition, wait approx. 3 minutes, check dipstick, then fill to MAX. See Repair Manual for details.Turbo engines only: After changing
oil & filter, start & run engine at idle till oil pressure light goes out. DON’T rev engine, this could cause damage/ failure of turbocharger .
©MANUAL TRANS: 02J:Use mineral oil, SAE 75W90, Part No. G 052 726 A2, 02M: Use synthetic oil, SAE 75W90, Part No. G 052 171 A2.
¢AUTOMATIC TRANS: Use VW ATF, Part No. G 055 025 A2(1 liter container). Life-time filling, initial fill quantity is for reference only. Only replace after repair
(i.e. when removing oil pan). See Repair Manual (VESIS) for details on filling after repair.
£DIFFERENTIAL AUTOMATIC TRANS: Combined with Automatic Transmission. See Repair Manual(VESIS) for details on filling after repair.
¤COOLING SYSTEM: Use only phosphate-free coolant G 012 A8F A4, PURPLE COLORED. DO NOT INTERCHANGE OR MIX older G11(ZVW 237 105),GREEN
COLORED.This can result in serious damage to the engine. However, it may be mixed with ZVW 237 G12, PINK COLORED. Frost protection is required down
to approximately -25_C (-13_F). In countries with arctic climates, frost protection is required down to approximately --35_C(--31_F). The anti-freeze ratio must
beaminimumof 40%, asotherwisefrost protectionis reduced. Therecommendedmixtureratio is50:50.If greaterfrostprotectionisrequired(very coldclimates),
theamountofG012A8FA4canbeincreased,butonlyupto60%.Thisprovidesfrostprotectiontoapprox. -40_C(--40_F).Donot reducethe coolantconcentration
by adding water, even in warmer seasons and in warmer countries, as cooling effectiveness will be reduced.
¥POWER STEERING: Hydraulic oil G002 000. Do not use ATF.
¦WINDSHIELD W ASHER: Concentrated ZVW 177 901/903/904/906.
§A/C REFRIGERANT OIL: Use PAG oil , Part No. G 052 154 A2 with R-134a.
Note:
Convertible top oil is: G002 000. Refer to VESIS for proper usage.
NOTE: Part numbers are for reference only. Always check with your Parts Dept. for the latest parts information.
