© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
© Copyright 2009, Alliance Laundry Systems LLC
All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any
means without the expressed written consent of the publisher.
201143
1
Table of
Contents
Section 1 – Safety Information .........................3
Locating an Authorized Servicer ............................ 5
Section 2 – Introduction ....................................6
Model Identification ............................................... 6
How Your Washer Works .................................... 10
Customer Service ................................................. 12
Nameplate Location ............................................. 12
Section 3 – Troubleshooting............................13
1. No Hot Water ................................................... 14
2. No Cold Water .................................................. 15
3. No Warm Water ............................................... 16
4. Water Fill Does Not Stop At Proper Level ...... 17
5. Timer Does Not Advance ................................. 18
6. Motor Does Not Run ........................................ 19
7. No Agitation ..................................................... 20
8. Constant Agitation ............................................ 21
9. Washer Overheats, Cycles On Motor
Thermal Protector, Switch Actuator
Kicks In and Out ................................................... 22
10. Slow Spin ....................................................... 23
11. No Spin ........................................................... 24
12. Constant Spin ................................................. 25
13. Washer Stops In Cycle; Quits After a
Couple Loads; Is Intermittent ............................... 26
14. Washer Is Locked Up Or Binding .................. 27
15. Outer Tub Does Not Empty ............................ 28
16. Excessive Vibration ........................................ 29
17. Water Leaking From Outer Tub ..................... 30
Section 4 – Adjustments ..................................31
18. Leveling Legs ................................................. 31
19. Pressure Switch .............................................. 32
20. Belt (Agitate and Spin) ................................... 32
Section 5 – Test Procedures ............................33
21. Motor Test Procedure ..................................... 33
22. Mixing Valve Solenoid Test Procedure ......... 34
23. Temperature Switch Test Procedure .............. 34
